Product ID:390 SIKADUR 31 HI-MOD GEL
MSDS Date:03/22/1985
FSC:6850
NIIN:00F014635
MSDS Number: BJVNN

SIKA CORPORATION

875 VALLEY BROOK AVENUE
LYNDHURST, NJ 07071

Emergency Phone: (800) 424-9300

Info Phone: (201) 933-8800

Cage: OPMN0

SIKA CORPORATION

LYNDHURST, NJ 07071

Telephone: 800-424-9300

Cage: OPMN0

SILICA AMORPHOUS HYDRATED, SILICEOUS EARTH, FUMED

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 17%

OSHA PEL 80 MG/CUM (%SIO2+2)

ACGIH TLV: 0.2 MG/CUM RESP/DUST

ZINC OXIDE

CAS: 1314-13-2

RTECS: ZH4810000

Fraction By Weight: 4%

OSHA PEL 15MG/M3 TDUST/5 FUME

ACGIH TLV: 10MG/M3 TDUST; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: IRRITATION & SENSITIZATION.
EYES/INHALATION: IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES/INHALATION: IRRITATION. SKIN: PROLONGED &
REPEATED CONTACT MAY CAUSE IRRITATION & SENSITIZATION.
Medical Cond Aggravated by Exposure:ASTHMA TYPE CONDITIONS, BRONCHITIS,
OTHER RESPIRATORY CONDITIONS, RECURRENT SKIN ECZEMA, &
PRESENSITIZATION TO PRODUCT.

First Aid:SKIN/EYES: FLUSH W/WATER FOR AT LEAST 15 MINUTES. INHALATION:
REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:>200F
Extinguishing Media:FOAM, CO2, WATER FOG
Fire Fighting Procedures:USE AIR SUPPLIED RESCUE EQUIPMENT.
Unusual Fire/Explosion Hazard:PRODUCT IS NONCOMBUSTIBLE.

Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT & CONTAIN.
FLUSH W/LARGE VOLUME WATER.

Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM SPARKS &
OPEN FLAME. DON'T STORE OR MIX W/STRONG OXIDANTS. AVOID BREATHING
OF VAPORS. USE ONLY W/ADEQUATE VENTILATION.

Respiratory Protection:WEAR NIOSH/MSHA APPROVED VAPOR RESPIRATOR.
Ventilation:PROVIDE ADEQUATE LOCAL EXHAUST/MECHANICAL VENTILATION.
Protective Gloves:DISPOSABLE PLASTIC OR RUBBER
Eye Protection:GOGGLES
Other Protective Equipment:AS REQUIRED
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
WT/GAL: 12.1 LBS.

Vapor Density:>AIR
Evaporation Rate & Reference:SLOWER THAN ETHER

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS & OXIDIZING AGENTS
Stability Condition to Avoid:EXOTHERM WHEN CURING IN MASS, SPARKS, &
OPEN FLAMES
Hazardous Decomposition Products:CO, CO2, & NITROGEN OXIDES

Waste Disposal Methods:CONTROLLED BURNING OR CURE & BURY IN ACCORDANCE
W/LOCAL, STATE, & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.